SVS Electric Steam Boilers

Sussman SVS Electric Boilers are safe, versatile easy to-use heat sources for low or high pressure steam. Applications include steam for:

  • CHEMICAL TANKS
  • REACTORS, DISTILLATIONS & AUTOCLAVES
  • DYESTUFFS
  • FOOD PROCESSING
  • JACKETED VESSELS FOR PROCESSES
  • PIPE TRACING
  • VISCOUS MATERIAL
  • FUEL OIL LINE HEATING
  • ANTIFREEZE PROTECTION
  • COMFORT HEATING & HUMIDIFICATION

ENGINEERED FOR:

  • EASY INSTALLATION
  • AUTOMATIC OPERATION
  • CLEAN, FUME-FREE, QUIET RELIABLE STEAM AT THE TURN OF A SWITCH
  • ALTERNATE SOURCE OF STEAM WHEN MAIN BOILER IS NOT IN USE
  • NO ON-SITE FUEL COMBUSTION
  • LOW MAINTENANCE
  • NO FUEL DELIVERY/STORAGE PROBLEMS
  • FACTORY TESTED - READY TO OPERATE
* Name:
Company:
Address 1:
Address 2:
City: State:
 		Zip:
* E-mail:
Telephone:
Fax:
  Voltage/Phase Electricity at Job Site:
 
  KW, BHP or BTU Required:
 
  Pounds Per Hour of Steam:
 
  Incoming Water Pressure:
 
  Desired Operating Pressure:
 
  Optional Equipment:
  Motor/Pump
Condensate Return System
Automatic Blowdown
Blowdown Separator
Step Sequencer
Transformer
  Application:
 
  How Did Your Find Us
 

SVS STANDARD FEATURES:

  • INSULATED ASME CODED AND STAMPED STEEL, PRESSURE VESSEL CODE S, SECT. I, 150PSIG
  • BUILT TO UL, NATIONAL BOARD REQUIREMENTS
  • STANDARD 150PSIG DESIGN - HIGHER PRESSURE AVAILABLE
  • FULLY INSULATED VESSEL, 2" THICK INSULATION
  • ASME CODE SAFETY VALVE
  • NPT INLET/OUTLET FITTINGS UP TO 3 1/2", FLANGED INLET/OUTLET FITTINGS FOR 4" AND OVER. (SEE SPECIFICATION CHART)
  • VERTICALLY MOUNTED INCOLOY SHEATHED IMMERSION ELEMENTS COMPLETE WITH EPOXY END SEAL
  • NEMA 1, EPOXY FINISHED GASKETED/LOUVERED CONTROL PANEL AND HEATER ENCLOSURE
  • BLOWDOWN/DRAIN VALVE
  • PRESSURE GAUGE WITH ISOLATING STOPCOCK
  • LIQUID LEVEL GAUGE GLASS ASSEMBLY
  • BACKFLOW CHECK VALVE AND SOLENOID FEEDWATER VALVE
  • STANDARD PRESSURE RANGE 20-150 PSIG (HIGHER PRESSURES MAY BE AVAILABLE UPON REQUEST)
  • MODULATING PRESSURE CONTROL (STANDARD OVER 90A)
  • ELECTRONIC FEEDWATER CONTROL
  • BOILER OPERATING MODE INDICATOR LIGHTS
  • SUB-DIVIDED CIRCUIT FUSING, CLASS "J", HRC FORM 1
  • INDUSTRIAL RATED AMGNETIC CONTACTORS
  • MANUAL RESET HIGH LIMIT PRESSURE CONTROL
  • MAIN & AUXILIARY LOW WATER CUT OFF CONTROLS
  • 120V CONTROL CIRCUIT C/W ON/OFF SWITCH AND INDICATING PILOT LIGHT
  • 120VAC CONTROL CIRUIT TRANSFORMER WITH PRIMARY & SECONDARY FUSING

SVS OPTIONAL EQUIPMENT:

  • STEAM OUTLET GLOBE VALVE (150 PSIG)
  • TIMED AUTOMATIC BLOWDOWN SYSTEMS
  • AUXILIARY LOW WATER CUTOFF
  • MANUAL RESET LOW WATER CUTOFF
  • AUXILIARY HIGH PRESSURE CUTOFF, FOR AUTO OR MANUAL RESET
  • HIGH PRESSURE ALARM
  • LOW PRESSURE ALARM
  • AUDIBLE ALARM WITH SILENCER
  • PILOT LIGHT FOR EACH HEATING STAGE
  • MANUAL OFF/AUTO SWITCH FOR EACH HEATING STAGE
  • VOLTMETER, COMPLETE WITH 3 POSITION SELECTOR
  • WATTMETER
  • AMMETER W/3 POSITION SELECTOR
  • UNFUSED DISCONNECT SWITCH
  • SAFETY DOOR INTERLOCK SWITCH
  • MOTOR STARTER WITH OVERLOADS
  • FLANGED INLET/OUTLET
  • VACUUM BREAKER
  • kW-HR METER
  • GROUND FAULT INDICATOR


<<View SVS Spec. Sheet>>

View SVS Brochure